Forklift Battery safe use and maintenance of the six points

A daily inspection
1, the liquid: a liquid level lower than the nominal, will shorten battery life, but the electrolyte is too small will result in heat damage to the battery, therefore, must always pay attention to the electrolyte solution is sufficient.
2, terminals, wires, cap: You must always check the battery terminal junction, and junction wires caused by oxidation due to corrosion, also check whether the deformation of the cap, if there is fever phenomenon.
3. Second, the maintenance battery leakage, the surface should be ready to make the battery clean and dry.
1, water: the level prescribed by the addition of distilled water, do not add water in order to extend the interval and add too much distilled water, add too much water will overflow cause electrolyte leakage.
2, the charging: the battery during charging gas is produced, the charge should be kept ventilated place, no fire around the simultaneous charging of oxygen, acidic gases generated in the process will have an impact on the surrounding. During charging charging plug will disconnect arcing, will shut down after charging machine, unplug it before. After charging the rough terrain fork lifts stuck around a lot of hydrogen, does not allow any open flame, should open the cover on the battery charge.
3, terminal, wire, cover maintenance: must be specified by the manufacturer of professional and technical personnel before proceeding.
4. Clean: If dirty, you can clean it with a damp cloth, if very dirty, it is necessary to remove the battery from the car, after washing with water to make it dry naturally.
Third, custody
1. Storage place: can not make a short circuit; rain and cause a short circuit may occur due to a fire, and may produce a small amount of hydrogen, the battery must be stored in a ventilated, cool place.
2, scrap batteries: energy waste batteries are still there, the

battery powered forklifts

should be stored for safekeeping in accordance with the methods used.
Fourth, the operation of the electrolyte
1. Check the specific gravity: Use a hydrometer to check the proportion of inhalation, do not let the electrolyte spill out when the job is, and to wear protective equipment.
2, the operation except to check: should professional advice, especially electrolyte (sulfuric acid) when the supplement.
3, electrolyte leakage: Because the battery tipping, breakage resulting in electrolyte leakage, emergency treatment should be carried out immediately (see emergency matters)
Fifth, end-of-life battery operation

1, the end-of-life battery operation: When the YTO forklift

 near the end of life, single-cell battery electrolyte within the abatement very fast, distilled water should be added every day.
2, treatment of waste batteries: For waste batteries, taking electrolyte, the battery exploded. Can discuss whether the recovery from the battery manufacturer.
Sixth, emergency treatment
An electrolyte spilled on the skin: Flush with plenty of water
2, the electrolyte splashed in the eyes: Flush with plenty of water, and then receive professional medical treatment
3, electrolyte spilled into the clothes: immediately took off his clothes, rinse with water and then rinse with a weak alkaline soap.
4, electrolyte leakage: the electrolyte from leaking to the outside immediately with lime, strong carbonated soda or carbonated soda, etc. neutralized and rinsed with plenty of water.