Forklift Battery Safety

                                             2.5 tons rough terrain forklift Battery Safety

First, the end-of-life 1.5 ton battery forklift operation 1, end-of-life battery operation: When the battery near the end of life, single-cell battery electrolyte within the subtractive very fast, distilled water should be added every day. 2, treatment of waste batteries: For used batteries, out of the electrolyte, the battery exploded. Can discuss whether the recovery from the battery manufacturer. Second, an emergency treatment, the electrolyte splashed on skin: Flush with plenty of water 2, electrolyte splashed in the eyes: rinse with plenty of water, and then receive professional medical treatment three electrolyte spilled into clothes: Immediately take off clothes rinsed with water and then rinse with a weak alkaline soap. 4, electrolyte leakage: the electrolyte from leaking to the outside, immediately with lime, soda or carbonated soda carbonate strong like for neutralization, and with plenty of water three, routine inspections 1, level: below the rated level, the shorten battery life, and too little will result in the battery electrolyte heat damage, therefore, must always pay attention to the adequacy of the electrolytic solution. 2, terminal, wire, cover: You must always check the battery terminal joints, corrosion and connection wires caused by oxidation, and check whether the deformation of the lid, is there fever phenomenon 3, Appearance: dirty surface will cause the battery leakage, should be ready to make the battery surface clean and dry. Fourth, maintenance 1, add water: the level prescribed by the addition of distilled water, do not add water to prolong the interval of distilled water and add too much, add too much water will overflow cause electrolyte leakage. 2, charging: the battery charging process will produce gas, the charge should be kept ventilated place, no fire around, while charging oxygen, acid gases generated in the process will have an impact on the surrounding. During charging unplug the charger plug arcing, after charging the machine turned off, unplug it before. After charging the battery stranded around a lot of hydrogen, does not allow any open flame, should open the cover on the battery charge. 3, terminal, wire, cover maintenance: must be specified by the manufacturer of professional and technical personnel are available. 4. Clean: If dirty, you can clean it with a damp cloth, if very dirty, it is necessary to remove the battery from the car after washing with water to make it dry naturally. Fifth, keep one, Storage place: not to make it a short circuit; cause a short circuit may occur due to rain fire and may produce a small amount of hydrogen, the battery must be stored in a ventilated, cool place. 2, scrap batteries: waste battery power is still there, should be kept in accordance with the methods used to store batteries. Six electrolyte operating a check gravity: a hydrometer to check the use of inhaled proportion, do not let the electrolyte spill out when the job, and to wear protective gear. 2, in addition to checking the operation of: professional advice should be, especially the electrolyte (sulfuric acid) when supplemented. 3, electrolyte leakage: As the battery tipping, breakage resulting in electrolyte leakage, should be urgently addressed immediately (see emergency matters)